Mesabi Metallics Company LLC

Safety activity

1. inspection2026-06-09F0178C2

   103 (g) Written Notification Hazard Complaint Inspectio · 1.5 on-site hours

2. accident2026-06-08220261660010

   SLIP OR FALL OF PERSON · NO DYS AWY FRM WRK,NO RSTR ACT

   Accident narrative

   EE was coming down stairs which were wet from rain. EE stated EE headed down the stairs and the handrail was wet, EE stepped wrong and rolled EE's ankle. This caused pain to the outside of EE's ankle and to the top of the foot.

3. accident2026-06-02220261660005

   HANDLING OF MATERIALS · ALL OTHER CASES (INCL 1ST AID)

   Accident narrative

   EE was in the process of cleaning the shaft of the fan. Crew recognized the hazards of the insulation pins prior to starting work and had bent them down to decrease the potential of sticking themselves. During the cleaning of the fan shaft EE bent elbow to move and caught back of arm/elbow with the pin causing sharp point to impale the tip into skin. Caused a small puncture wound.

4. accident2026-05-28220261660006

   MACHINERY · ALL OTHER CASES (INCL 1ST AID)

   Accident narrative

   Welding when a piece of slag fell and burned through EE's jeans.

5. accident2026-05-28220261540010

   STEPPING OR KNEELING ON OBJECT · DAYS RESTRICTED ACTIVITY ONLY

   Accident narrative

   kneeling while wiring a vfd, this building has concert floor, dry and level.

6. accident2026-05-14220261410001

   STRIKING OR BUMPING · NO DYS AWY FRM WRK,NO RSTR ACT

   Accident narrative

   EE was walking on grating that had been installed in slurry bridge. Crew was in the process of lifting the slurry tank agitator gearbox to do a test fit for the millwrights. Piece was overhead, EE was watching the piece and not watching where they were in relation to the open hole. EE stepped off the grating, there is a clip on the beam that EE struck shin on causing cut about 3".

7. accident2026-05-13220261380004

   SLIP OR FALL OF PERSON · DAYS AWAY FROM WORK ONLY

   Accident narrative

   Employee was cleaning out the thickener tanks on the south end. While cleaning, employee slipped on mud. Employee fell and twisted left knee.

8. inspection2026-05-11F03491E

   103 (g) Written Notification Hazard Complaint Inspectio · 2.0 on-site hours

9. accident2026-05-09220261470010

   MACHINERY · NO DYS AWY FRM WRK,NO RSTR ACT

   Accident narrative

   Employee lost control of grinder and cut EE's leg.

10. accident2026-05-09220261340001

    HANDTOOLS (NONPOWERED) · NO DYS AWY FRM WRK,NO RSTR ACT

    Accident narrative

    EE and crew were turning a floor brace using a sleever bar in one of the bolt holes. Brace was on flat side. EE standing on E side of the N/S aligned brace pulling on the bar toward EE. In the line of fire when piece reached tipping point where crew needed it for rigging to put in place. Piece reached tipping point, EE lost footing. The sleever bar struck EE's leg causing cut.

11. accident2026-05-07220261340003

    HANDLING OF MATERIALS · NO DYS AWY FRM WRK,NO RSTR ACT

    Accident narrative

    EE and partner were setting up a jig to assist in fit up of the ring to the duct work. EE was holding the piece low to assist in getting the jig welded to the duct. EE's partner stuck EE's weld rod to tack up the piece and rod got stuck. When EE went to remove the rod, the piece fell and landed on EE's pinky fingertip which caused a laceration. EE did have gloves on.

12. accident2026-05-05220261340004

    NONPOWERED HAULAGE · NO DYS AWY FRM WRK,NO RSTR ACT

    Accident narrative

    While moving a skirt that goes on to a conveyor, weighing approx. 150-200 pounds, while on a skate it slid off and pinched left thumb. EE was rushing and did not wait for other staff to secure it before moving it.

13. inspection2026-04-28F033ED9

    103 (g) Written Notification Hazard Complaint Inspectio · 11.0 on-site hours

14. accident2026-04-22220261180001

    HANDLING OF MATERIALS · NO DYS AWY FRM WRK,NO RSTR ACT

    Accident narrative

    EE was assisting spreading a telehandler forks, while they tilted mast down to facilitate tine adjustment, the right tine was moved, after EE began sliding the L tine outward. During this process, the R tine slid back unexpectedly. EE attempted to reposition the R tine w/EE's gloved L hand, EE L middle finger got pinched between tine and mast's lower bar. Skin tear on L finger.

15. accident2026-04-10220261110006

    MACHINERY · NO DYS AWY FRM WRK,NO RSTR ACT

    Accident narrative

    Employee was using an oxygen/acetylene torch to heat and shape rebar material. The worker inadvertently tripped over the torch hose, which resulted in a loss of balance. As a result of the trip, the worker unintentionally made contact with the active torch flame, causing a burn to the left wrist, just above the cuff of the glove.

16. violation2026-04-095115502

    56.16007(a) · $151.00 proposed

17. violation2026-04-075115501

    56.11016 · S&S · $177.00 proposed

18. violation2026-04-075115500

    56.14207 · $151.00 proposed

19. violation2026-04-065115499

    56.16005 · $151.00 proposed

20. accident2026-04-03220261040007

    HANDLING OF MATERIALS · DAYS AWAY FROM WORK ONLY

    Accident narrative

    Cable pull, picking up cable for refeeding into vault. Cable was being fed into vault and pulled out by hand to get it prepped for next pull into building from this vault.

21. violation2026-04-015115498

    56.12032 · $151.00 proposed

22. violation2026-04-015115497

    56.12018 · $151.00 proposed

23. violation2026-04-015115496

    56.14207 · $151.00 proposed

24. violation2026-03-315115495

    56.4201(b) · $151.00 proposed

25. accident2026-03-27220260920003

    HANDTOOLS (NONPOWERED) · NO DYS AWY FRM WRK,NO RSTR ACT

    Accident narrative

    Employee was holding a bull pin with their right/dominant hand and missed, hitting it with a hammer with their left hand and instead hit their right hand with the hammer.